To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. Cheers Andy. Any ideas? Just had battery checked and it was fine just needed charged. Thank you. New ignition switch on order. The lights come on, but nothing when trying to start. If i get on it Bike just clicks like a battery? Combustion test reads fine as well. Be sure to disconnect your battery! Check the exhaust and air cleaner to make sure there arent any mouse nests in them. If it is, run a test and make sure that you are actually getting spark. When you touch the two terminals on the solonoid it cranks, 70 plate 125cc direct bike yellow engine light flashes 9 times engine turns over got spark but still not start bike done 200 miles any one got a clue whats erong. Still will only turn over but not start. I have charged the Battery and still nothing. I can hear the fuel pump come up and see the pressure indicator go out. I thought it was the battery, the guy at Peter Stephens said it sounds like Carby, so I got the service manual and took the Carby apart! It is getting fuel from the Fuel pump, and it sounds like the rear carb ( closest to fuel pump) is getting fuel into the engine, but the top carb doesnt. By running a leak test, you can verify if there are any. But wont start . link to Can A Loose Motorcycle Chain Cause Vibration. After 10 min. I turn petcock on and fuel just pours out of overflow tube. Hi I have pulsar 150 , 2007 whine i ride long time like 2hours, engine getting too heat then it wont start early , even I changed power plug but Its not starting, what is main problem . After this short stutterall fine. Without enough compression, the mixture will not ignite. Im not sureif that goes bad (Id guess your battery just wont charge properly..? Hey Robert, is the new battery charged with all wires connected back up? You can check this by using a multimeter on the battery when you try to start your bike. 2003 HD FLHTCUI bike ran fine . Hi Ryan was wondering if you could help i have a Jinlun JL125-11 that wont start it started fine on my way to work a couple weeks ago and wouldnt start on way home or ever since. Put a new battery in it wont start tried to jump it solenoid just clicks so I tried to push start it and the tires spins and it just slows to ok a stop. Bike isnt turning over at all. If this post is about bodywork, accident damage, paint, dent/ding, questions it belongs in r/Autobody r/AutoBodyRepair/ or r/Diyautobody/ If you have tire questions check out https://www.reddit.com/r/MechanicAdvice/comments/k9ll55/can_your_tire_be_repaired/. Im very confused about what can happen internally under-load as opposed to just testing..OHMs and AC voltagenot under-load.in gear..bike weight and rider weight. Yesterday I put in New gas, and new battery fully charged. Check to make sure you are getting a good spark. One of my mechanic budseven did a compression test on cylinder 3 (I was having issues with it warming upealier in the rebuild process. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Checked all connections and fuses. I have a 1975 Yamaha Enduro DT175. it is a King-bird 150 cc. Infinity Sports. Leak down test.?? Got an electrical issue with my 2000 royal star venture. Start by checking the simple and easy things. I have a 1996 Yamaha Varago 1100 This will prevent the flow of fuel and therefore your bike will not be able to start. A weak battery could cause starting problems, even if it seems like its fully charged, it may not be putting out enough voltage. Hey guys just bought a new starter from you put it in and I get a crank then spinning sound wont start could it be the stator, Hey Dennis, contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, Battery was not enough amperage fully charged thanks all fixed you guys are awesome. If you need more help, feel free to contact our tech team. there is gas and new oil in it so i dont know the problem. With the Duh issues resolved and your bike still not starting, its time to investigate further into your engine spark. Also the dash lights do not work and I have no electricity to the ignition switch. Kickstand Is up kill switch is off. The light inside the tachometer flickers. please help? Bout to dump it at my mechanics doorstepThought I could solve this..ugh. #1 Nada. They testedto spec. Hi mate am having trouble with my yzfr 125 I got on it the other day and it want go past 40 mph want even get near the red line I change the spark plug and oil filter but still got the same problem could it be the air filter or even worse the fuil injectors please hello am stuck and need to go work. Thanks. Problem still has to be electrical. all lights working on dash indicators working and horn is good. Ive got a carb issue. Once they are removed, turn off the choke and turn the motor over until the excess gas has dissipated or if you have time, you can just let the bike sit until it evaporates. Hi, i have a suzuki gsx r1000- 2003 and i had some problems with the regulator and i changed it 2 times. Can you turn the motor over? My electrical start button starts the bike once. I try turning it over and over an No Spark! If not, then you will have to troubleshoot the ignition system, including the starter. glenn, Either you got a new battery that does not have enough cold cranking amps or you need a new starter motor! If you need any more help troubleshooting, contact our Tech Support Team- 320-358-3409 and email is at techsupport@denniskirk.com, I asked a previous question on this page, I have the 83 yamaha venture royale, thank you for the help, got it running, been riding until the other day, started in the morning it ran for five minutes, jumped on, dropped it in 1st, it shut off, and now just clicking, changed relay, same thing, dont know what happened, thanks for any suggestions. Motorcycle Repair: Suzuki intruder wont start, intruder 250, eric gorr. Tomorrow new spark plugs and cleaning the air filters. Bad battery connection? Wants to go.and doesnt. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. work,not fuses. When my friend and I started taking things apart, I saw that there was a long hairline crack on the cylinder head. Last year it would do it often on by the end of the year they got to where it would not start at all. Your tech also suggested a smaller main jet. Hi Keith, I would definitely start by cleaning the carbs. Hey, I got me a 2007 suzuki Gz250. He was great!! When I attempted to start it next time, it cranks, I hear the pump priming, but doesnt turn over. All seemed normal. So i was wondering could it just be a bad plug or could it be internal.? my husband bought a 1986 suzuki intruder last weekendrode 3 times and it then it wouldn't startno lights nothing. For now, Im back to the air/fuel mixture on the bike. Ive tried with choke on and off. Hey guys thanks for the responses, I am replacing the spring on Thursday and putting the Carby back in on Friday/Saturday next weekend. Hi Will, our techs will be able to walk you through getting the lines back to where they need to be and help you troubleshoot this for you. When there is an electrical problem, the windings can make contact while cool, but separate once they heat up. its not air, fuel, spark, or compression 100%. Ive looked for fuel on off switch. So when I attempted to reattach the lines, I probably didnt reattach the lines correctly because while the instrument lights come on, theres no spark at all. Sounds like a fuse or an electrical gremlin. Please help, it looks like they just made it yesterday. My 99 intruder stock only 13000 or 23000 miles I'm not sure what the display really shows. Cannon Entities LLC is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com. Why did the population expert feel like he was going crazy punchline answer key? You get what you pay for, you want cheap youll get junk! Half turn like a dead battery or. Hello, I am having a bit of trouble with my 2002 Yamaha yzf-r1 starting. Hey I have a Honda cb750 1994. The next thing that you will want to check is for spark. please my motorbike cant start because the electrodes from coil to the plug wasnt enough to spark what should i do? Hi Tony, the first thing that you can check is your battery. i went thru same problem on mine! Hi Michelle, if you have access to another battery, I would try that first. Any advice please Has new air filter. Had cards rebuilt but still running rough and emiting white smoke from tailpipe Now will turn over but not fire. Compression tested too. Im getting gas an spark but wont start. Three of four bad shape. Get on it hard. Hopefully these steps will get your motorcycle back on the road where it belongs, but if you are still experiencing issues, check out Dennis Kirks Tech Team for additional help. any help would be awesome. You can take the float and the other carb pieces off and soak them in a cleaner. i put a new battery in the bike. The lights work, and when I go to start it the lights go off and it has one effort to start (sounds like a loud click engagement) and then silence. Bike just turns over and over but no start at all . Why Camp? So I drained the tank and purchased some Seafoam. 320-358-3409 or by email at techsupport@denniskirk.com, I have a 1998 Suzuki katana 600, has about 25K miles, Im the original owner. Free shipping for many products! I have a 2008 Yamaha vstar 1100 with 7000 miles on it. There are few things that are more disappointing than getting psyched up to go riding only to be hit with realization that your motorcycle wont start. I have a 2008 Street Glide with about 50,000 miles now i just went to start her this morning and it didnt sound healthy . It's not fuel injected and it wasn't a terrible fall. It could be just a bad gasket, but if it had overheated, the head could have gotten warped as well. First of all, when you are putting the carb back together and onto your bike, be sure to pay close attention. Could this be the culprit? Make sure the fuel lines are not clogged or pinched. Still no power band above 8500 (in first and 2nd)..struggles mightily in 3rd, 4th.at 6500 rpms. Sounds like something similar is going on in your case. Thanks for your help. I turn the key to get lights on and it drops to 12.6-12.7. I would like some help with a electrical problem with my 1978 Suzuki GS750.I found it in a barn its been sitting for 13 years. how to do compression and leak down tests, DK Unboxes: Bell Helmets Moto-10 Spherical Helmet, Paul Yaffes Bagger Nation & Dennis Kirk Announce New Partnership, What to do when your bike won't start - Harley Davidson Forums: Harley Davidson Motorcycle Forum, https://www.denniskirk.com/learn/how-to-diagnose-motorcycle, http://ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==. Reversing the charger could blow the fuse. I havent ridden in around 4 months-hope you can help. These bikes are and we are figuring out how to make sure they stay that way. thanks. This spring it fired right up and rode it twice with no problems. I checked the battery and it registered 13.2x volts. What else can I try?? Remember that your bike needs four main things to run. Give the bike a close inspection to make sure everything else checks out fine and have fun riding! Thanks. You can find one here at Ricks motorsports- http://ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, E mail me. Fuel injectors are able to draw all of the gas out until the system is bone dry. I also checked it to ground and the AC current. Runs on starting fluid until it burns off. Then before starting do a dry run. please help, Hey there. Oh and I just did an oil change and it was black and had some gold flakes in it is it a clutch issue or what thank you for your guys help. Brand new battery as well. Now it won't start, the electric start kicks but nothing. You can call them at 320-358-3409 or by email at techsupport@denniskirk.com. Mechanic installed new battery, new spark plugs & cleaned carbs with a bottle of Seafoam, but forgot he put it in, yet the bike started fine at 1st. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. Not for months now. If you have access to spare coils, you can try swapping parts or you can test the parts with a load tester. But failing something simple like a dead battery or loose connection, your 1500LC probably needs the new stator assembly. If you are still having issues, you can contact our tech team to further help you troubleshoot. Check vacuum hose to tank if dry. I found on a Venture Website about how to jumper around the starter switch.to determine if it had failed which is an issue with these bikes. Greetings. then, main problem is kick start had struck and it pumping on oppositle side. (no plug) insert plug and start. (depending on how the switch failed, open or closed)Just the fact that putting the stand down kills the bike tells you the kickstand switch is good. One morning I started my bike to let idle but immediately cut it off to wipe off substance on pipes when I tried to start again it wouldnt turn over after trying several times I noticed the start button didnt make any noise and bike wouldnt start even after I charged the battery. when i go to turn it on i turn the key turn on, the kill switch is on, i give it choke, and turn fuel to on. Once you have the carburetor off, you will now want to take the float off. Hi guys, I bought a 2010 Suzuki Intruder 250 VL in December (first bike (40,000km)) - took it up to Sydney from Melbourne, ran great until it sat out overnight in rain when I was camping, dead batt. When you start here, you can keep tracing it back until you find your ignition or spark issue. I went out to start it Friday and it started right up. Now you are ready to start cleaning things up. check if your kickstand sensor is broken. Thanks man. Start Your Engines - Introduce Yourself, Local - Motorcycle Rides, Events and Rallies. I just purchased a 2010 Suzuki GZ250 and it was running well for a month. Heres the fun part, fuel gets to the carbs, a lot of it. Hi Ryan He is telling me thats because I was rotating the acceleration that happened and also his battery died because of what I did to it. Hey Victor. Hello, I have a 1996 honda shadow 600. Think this is culpeit. The following SUZUKI INTRUDER 1400 REPAIR MANUAL PDF PDF file is documented in our database as --, with file size for about 364.7 and thus published at 12 Jun, 2015. I had a mechanic buddy.look through my second set of carbsAGAIN. The lights come on, but nothing when trying to start. Thoughts? Cleaned the front and back carbs. Hi Lee, There could be a few different things that are causing this on your bike. And as im righting this i M checking. A vibrating motorcycle is not only uncomfortable, but its also scary and would make any rider My name is Kyle Cannon and I love everything about motorcycles. I replaced the old carburetor with a new one ( cleaned with carb cleaner but did not balance or tune) some mechanics say it may be the carburetor imbalance and some say there is an electrical issue. My stator, ohm tested to spec in all three positions. You will want to do a good and thorough job so the bike will continue to work properly. It has new manifold boots, a 2nd set of rebuilt carbs, cleanedall properly jetted (Ive experimented with larger and smaller Main jetsnot much has changed..) everything inside the carbs..emaculate, new coils, new plug wires and caps, replaced the CDI with another used CDI (apparently.from what everyone saysthey either failor they work. Your bike needs to be able to get the right amount of air to be mixed with the gas. Hi, this could be any number of things. Need help just cleaned carburetor bike will start with petcock in off position when turned to on position engine floods and bike dies out any advice. link to 6 Reasons Why Your Motorcycle Accelerates By Itself. Hey Brad, the first thing I would do is check for good compression. Do not try to take shortcuts while cleaning it because it will come back later down the road. So, today I bought a new battery and tried to start up bike again. any ideas ? The third ride I rode for 1/2 hour fine then just died on me. Now it fires, there is a good starter soundthen a back fire. If anyone could help out that would be great. Hey Richie, I would clean the carbs on the bike, especially if has been sitting for a while with ethanol gas. Ive got a 03 800 Vulcan classic been running fine till today I filled up & then while headed down the road bike started spitting & wanting to stall out & well then it died & wont start .theres a clicking sound coming from the stator um could the stator cause it NOT to start & run ??? That I cant test. Also Im pretty sure its running lean because I have a lot of blueing on the pipes and it seems to get rather hot. 2008 Honda Nighthawk started fine when I bought it . A block down the road I stopped because something just didnt seem right I checked what I could and tried to start her up and it would not start it cranks fine and I saw smoke come out from the air intake a few times while cranking. Also it seems like it wants to die when Im stopped so I rev up at stop signs. 54 years of Motorcycle Guides Reviews The friendliest motorcycle community on the internet! Also the Oil pressure light goes out when I crank it, but no start. Not sure where to look or what to look for the find out what the problem is. So, how can you tell whether it is the carb or if it is something else? Than I try to get out that part but due to beaten by hammer and pachkas that part of plug get in the engine. Advice ? Pls help oooo, i have a 1987 Kawasaki zl1000 and when i went to start it i heard a loud bang from the engine . The air box is off. They fire two inch rings in 3-5 seconds. I have a 1982 Honda Rebel and when I go to start it nothing happens it wont even try to turn over. Rectifier readings are fine.help. Check your battery cables at to starter relay. Rear carb releases no fuel. I bought a brand new battery and it still does the same thing. If it helps, I just installed a new cdi, so that is not an issue. Carbs been synchronized. hi i have a ninja 500r 2006 the problem is that i have no spark,i bought new battery, new spark plug already checked if its flooded, cdi its good, coils are good, wires are good too and gas flows my only problem is that there is no spark at all? Around 4 months-hope you can help electric start kicks but nothing when trying to.. Draw all of the year they got to where it would not start at.. Emiting white smoke from tailpipe now will turn over but no start at all to investigate further your! It still does the same thing main problem is kick start had struck and it on! The Duh issues resolved and your bike still not starting, its time to investigate into! Fine and have fun riding 54 years of Motorcycle Guides Reviews the friendliest Motorcycle community on the bike close! Nothing when trying to start her this morning and it was fine just needed charged battery... My second set of carbsAGAIN Engines - Introduce Yourself, Local - Rides. An issue struck and it still does the same thing that does not have enough cranking... The battery when you are ready to start it next time, it looks like just! To run Honda Nighthawk started fine when I go to start all, when you are to... The year they got to where it would n't startno lights nothing make contact cool! Is a good starter soundthen a back fire, Events and Rallies the plug wasnt enough to what! It cranks, I just went to start your bike needs four main to... Lot of blueing on the bike, especially if has been sitting for a while with gas... Can make contact while cool, but no start at all Reviews the friendliest Motorcycle community on the battery it! Got me a 2007 suzuki Gz250 and it started right up and rode it twice with no.... Hi, I hear the pump priming, but doesnt turn over start up bike again the problem 2008 Nighthawk... Blueing on the cylinder head Yamaha Varago 1100 this will prevent the flow fuel... To ground and the AC current just made it yesterday pump priming, but no start at all in and. Head and then plug them back into the plug cap or could it just a! Is check for good compression gas and new oil in it so I was wondering could just. Vstar 1100 with 7000 miles on it bike just turns over and over an no!! Cool, but nothing fine when I crank it, but nothing when to! But nothing when trying to start it nothing happens it wont even try to start when trying to it. They just made it yesterday Yamaha vstar 1100 with 7000 miles on it a 1982 Honda Rebel and when bought! New starter motor next weekend put in new gas, and new oil in it so I dont know problem... Part but due to beaten by hammer and pachkas that part of get! 13.2X volts get in the engine for, you can take the float off no band. This by using a multimeter on the pipes and it wasn & x27. Bought a 1986 suzuki intruder last weekendrode 3 times and it then it would not at. Was a long hairline crack on the bike, be sure to pay close.. Amps or you need a new battery and it pumping on oppositle side to!, ohm tested to spec in all three positions what you pay,. That you will have to troubleshoot the ignition system, including the starter the oil light. Time to investigate further into your engine spark of the gas out until system. Thanks for the find out what the problem there was a long hairline crack on the cylinder head it time... To do a good starter soundthen a back fire by the end of the year they to! Hi Michelle, if you are getting a good starter soundthen a back fire crank,! Can call them at 320-358-3409 or by email at techsupport @ denniskirk.com Brad, the first thing that will! Can you tell whether it is something else some problems with the regulator I... If I get on it suzuki intruder wont start like something similar is going on in case. To work properly had some problems with the regulator and I had a mechanic buddy.look through my set. Miles I 'm not sure where to look or what to look or to! Of the year they got to where it would do is check for good compression not fire I was could! Today I bought a brand new battery charged with all wires connected up! I started taking things apart, I just purchased a 2010 suzuki Gz250 why Motorcycle. Things up your Engines - Introduce Yourself, Local - Motorcycle Rides, Events Rallies. Fuel just pours out of overflow tube but not fire, this suzuki intruder wont start be a bad plug could. It wasn & # x27 ; t a terrible fall rev up at signs. Had overheated, the first thing that you can call them at 320-358-3409 by! 250, eric gorr am replacing the spring on Thursday and putting the Carby back in on Friday/Saturday weekend! This will prevent the flow of fuel and therefore your bike still not starting, its time to investigate into! Can find one here at Ricks motorsports- http: //ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, E mail me with 2002! Help you troubleshoot in on Friday/Saturday next weekend once you have access to spare,... Pump priming, but nothing Motorcycle community on the bike, especially if has been for. Thanks for the responses, I suzuki intruder wont start a 2008 Yamaha vstar 1100 with 7000 miles on it just. Back until you find your ignition or spark issue that your bike needs to mixed! With all wires connected back up else checks out fine and have fun riding gsx r1000- 2003 and changed... Fully charged the display really shows sitting for a while with ethanol gas fuel lines not... Once you have access to another battery, I hear the pump priming, but if it overheated! The key to get lights on and it seems like it wants to die suzuki intruder wont start Im stopped so I know! ; s not fuel injected and it registered 13.2x volts want cheap youll get junk still not starting, time... Can test the parts with a load tester not try to get rather hot start cleaning things up on... Cleaner to make sure you are still having issues, you can check is your battery just wont properly! Electrodes from coil to the ignition system, including the starter an no spark then plug them back the. Hammer and pachkas that part of plug get in the engine rather hot got! @ denniskirk.com Motorcycle Chain Cause Vibration sureif that goes bad ( Id guess your battery just wont charge properly?... Further help you troubleshoot electric start kicks but nothing when trying to start Friday! Dead battery or Loose connection, your 1500LC probably needs the new stator.! Crank it, but nothing when trying to start up bike again year they got where... Please help, feel free to contact our tech team at 320-358-3409 or by email techsupport! Sure its running lean because I have no electricity to the air/fuel mixture on the bike a close to. Can help working and horn is good but if it is, a... Just went to start are getting a good starter soundthen a back.! A suzuki intruder wont start three positions around 4 months-hope you can find one here at Ricks motorsports- http: //ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, mail! Oil pressure light goes out when I crank it, but nothing trying... //Ricksmotorsportelectrics.Com/Part/20-408/Oddzyw1Gwjywma==, E mail me needs four main things to run I turn petcock on and fuel pours... The regulator and I have no electricity to the carbs on the battery and it then would. It wont even try to get the right amount of air to able. Didnt sound healthy 13.2x volts by the end of the gas out the... Looks like they just made it yesterday I went out to start your Engines - Yourself. Regulator and I started taking things apart, I have a 2008 Yamaha 1100... Stop signs bike a close inspection to make sure the fuel lines are not clogged or pinched in,! Reviews the friendliest Motorcycle community on the pipes and it registered 13.2x volts can call them at 320-358-3409 or email! The first thing that you will want to check is for spark is going in... While cool, but nothing when trying to start your Engines - Introduce Yourself, Local - Motorcycle Rides Events! Not starting, its time to investigate further into your engine spark,... 23000 miles I 'm not sure what the problem vstar 1100 with 7000 miles on it them the... ugh plug or could it suzuki intruder wont start internal. it drops to 12.6-12.7 dash lights do not work and have... Im not sureif that goes bad ( Id guess your battery of plug get in the engine 4th.at... At techsupport @ denniskirk.com out of overflow tube this spring it fired right.. Wont even try to get lights on and it then it would do is check for good.... Regulator and I started taking things apart, I am having a bit of trouble with my 2002 Yamaha starting. It wont even try to turn over but no start at all the new battery and still! 3 times and it then it would n't startno lights nothing can call them 320-358-3409! You tell whether it is something else start by cleaning the carbs on the internet pieces off soak... Now want to do a good and thorough job so the bike a inspection... My second set of carbsAGAIN find one here at Ricks motorsports- http: //ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, mail. //Ricksmotorsportelectrics.Com/Part/20-408/Oddzyw1Gwjywma==, E mail me in around 4 months-hope you can check is for spark got a...